Having problems with your Karcher 2500 PSI Pressure Washer ?

Can you show me the unloader valve? I have a Karcher 2501


Answers :

Look for a black\015\012plastic cover with a silver snap on top; pry off the silver snap and\015\012lift off the plastic cover; next remove the two torx screws on the top plate\015\012then pull out the piston inside - if unable to lift out, start unit and\015\012watch it pop out - coat piston with lithium grease and reinstall

hope this helps
if it does please vote

Repair Help & Product Troubleshooting for Karcher 2500 PSI Pressure Washer

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

Can you show me the unloader valve? I have a Karcher 2501


Look for a black\015\012plastic cover with a silver snap on top; pry off the silver snap and\015\012lift off the plastic cover; next remove the two torx screws on the top plate\015\012then pull out the piston inside - if unable to lift out, sta ... Karcher 2500 PSI Pressure Washer

I have a Karcher HD3500 and was told Imay have a stuck unloader valve. Where is it and is there a diagram showing how to get to and clean?


HiThe unloader valveis HERE If you go to D-2 it is part numbers 8 to 13. If it is stuck it is not only important to free i ... Honda Karcher G2400HH-R Pressure Washer

Karcher pressure washer unloader valve sticking? I have the pump shown on page 3 of Karcher manual number 91392030. I removed the unloader valve, but am not sure if I have the entire assembly. I got the top seal and a spring. The bottom seal may be jammed in the pump.


... Karcher G3025OH Pressure Washer

My Karcher 4000 SHR Pressure Washer pressure pulses when operating. I have checked with Karcher Technical Support and all their trouble shooting procedures except checking the unloading valve. Where is this valve, how do I get to it and how do I lubricate it?


It sounds like your unloading valve is crudded up with mineral deposits and stuck in a partway open state. look for a plastic cover with a silver snap on top; pry off the silver snap and lift off the plastic cover; next remove the two screws on the ... Honda Karcher G4000RH Pressure Washer

Clean and unloader valve on Karcher hd3500 pressure washer -intermittent pressure on and off. Cleaned inlet screen. Think unloader valve is is under pressure knob? Will cleaning help?


Hi:Cleaning it is not enough. You need to make sure the o-rings are in good shape and grease it with a very very good waterproof grease. ... Karcher Pressure Washers

Unloader valve Thanks for the insight on my problem with a Karcher 550m. I have taken the pump motor out of the unit. How do I identify the unloader valve & replace it? There does not appear to be any other leaks. Is this the only part that needs replacing if pressure is down? Many thanks


... Pressure Washers

Karcher G3050OH Pressure Washer Spill / Unloader Valve (Bypass)


You should put 'locktite' on the male thread and screw it in all the way and lock it there. That is how it works ,the spring keeps the valve at the bottom closed during high pressure operation. When the gun is released the part with the o-ring is for ... Karcher 2500 PSI Pressure Washer

Unloader Valve - Karcher Pressure Washer


Where is the unloader valve locaed on a Briggs Stratton pressure washer? ... Honda Karcher G4000RH Pressure Washer

How do you locate/clean an unloader valve on a Karcher HD3000 pressure washer


... Karcher G3025OH Pressure Washer

Karcher unloader valve


... Pressure Washers

Karcher G2401 OH spraying water from unloader valve


... Pressure Washers

Karcher K3.91, lost some pressure and pulsing when trigger is release. stripped it down and checked all six valves and there all sealing as they should. i took apart the unloader valve cleaned and inspected and thats fine. there is NO water leeks anywhere or oil. preasure washer is 2 years old and gets used once a week for ten minutes. i really dont understand why its playing up


... Pressure Washers

I have a G2500VH pressure washer that has started to pulse when the trigger is squeezed. This happens if I use the 0,25, and 40 degree nozzles BUT if I use the one for low pressure(detergent use) it will hold pressure fine. I have changed the unloader valve, checked all the valves and seals ad they seem to be fine. What could be the problem?


Do you mean pressure on and off with the hp tips and smooth and steady with chemical tip? ... Pressure Washers

Our LG 6810 dishwasher has stopped cleaning. After the cycle the dishes are wet and covered in greasy clumps. We ran the test cycle and got the following: 3H/U3 11 22 33 44 55 66 04-2 32 33 0 (inlet valve) 35 36 37 38 23 (Thermistor) 3A 3A (beeped twice and showed 3A) 3A (beeped twice and showed 3A) Any advice you could give me would be appreciated. I have the service manual but have never done any type of dishwasher repair. I'd like to not have to replace this dis


1.) Take racks out of unit.2.) put both of the spray arms in the 12 o'clock position3.) Run the washer,once the washer has started wash cycle,open the door and ensure the spray arms have moved off of the 12 o'clock position. Write down re ... LG LDF6810 Built-in Dishwasher

I need to check the unloader valve on my Karcher 3000psi pressure washer. I was directed to your site for help. I just need to know what to unbolt to get to the valve.


... Pressure Washers

How to clean unloader valve on Karcher G4000SH


... Karcher 2500 PSI Pressure Washer

Have a Karcher 3000G pressure washer, low pressure. How do you remove the unloader valve?


Ask the professor. He knows everything about everything. I'm working on my degree now. Go to Youtube like he does. LOL ... Karcher 2500 PSI Pressure Washer

Where is the unloading valve on the 4000 karcher


... Honda Karcher G4000RH Pressure Washer

Poor pressure karcher g 2500 pressure washer with a 5.5 honda engine. No high pressure, hose pulsates as does water out of the outlet. have removed the unloader valve twice and cleaned it to no avail


I had this same problem on my pressure washer.the pump had some broken parts in it .i found my replacement pump on EBay. ... Karcher 2500 PSI Pressure Washer

We have a Karcher G2500VH pressure washer. If you start the engine with the trigger pulled on the spray wand it will run at full pressure until you release the trigger. after that, when you pull the trigger it will not have any more pressure than the water hose feeding it. Does it have an internal unloader valve? What is the part number?


Hi, Karcher calls the unloader valve a spill valve, this is a link to a full drawing/parts listing , and your fault description might well be a sticking /seized unloader(spill ) valve hope this helps ... Karcher 2500 PSI Pressure Washer

Karcher HD3101DR wHERE IS THE UNLOADER VALVE ON THIS UNIT CAN I GET A PICTURE/DIAGRAM???


Check out www.pressureparts.com ... Karcher 2500 PSI Pressure Washer

I have a sticking unloader valve in my Karcher 3050. where is it and how do I fix it?


Hello:Here is a schematic. On page 2.1, part #1 is the unloader valve. You need to remove it and lube it with a very good waterproof g ... Karcher G 3050 OHR Gas Pressure Washer

I have a Karcher HD 3101 pressure washer. The out pressure is not working. Is there a unloader valve that needs to be cleaned?


Yes, the unloader needs to be lubed. Send me a email at [email protected] with a discription of what you just listed and I will send you a pdf file on how to repair it. ... Karcher G3025OH Pressure Washer

Need help getting to an cleaning stuck unloader valve on a Karcher G 2400 HH Pressure washer. Thanks


The cart body makes this process a little confining but it can be carried out without removing the pump from the motor.\015\012\015\012Diagram courtesy of: ... Honda Karcher G2400HH-R Pressure Washer

Where is the unloader valve on G 4000 RH - Honda Karcher G4000RH Pressure Washer


... Honda Karcher G4000RH Pressure Washer
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.a-wash.org || Terms of Use || Contact || Privacy Policy
Load time: 0.0402 seconds